- El Segundo Energy Center in California officially inaugurated
- Two Flex-PlantTM-10 combined cycle power islands from Siemens Energy
- Installed capacity 550 megawatts (MW) for efficient and flexible electricity
- 300 megawatts (MW) in less than 10 minutes
- Power for approximately 450,000 homes in California
NRG Energy Inc. and Siemens Energy Inc. dedicated the El Segundo Energy Center located near Los Angeles, California, on September 12th. This is the second Flex-Plant to open in California after the nation’s first in Lodi that went into commercial operation last year. Siemens Energy has supplied and commissioned the two Flex-Plant-10 combined cycle power islands. In total they have an installed capacity of 550 megawatts (MW) – enough to supply efficient and flexible electricity to approximately 450,000 Californian homes.
Owned and operated by NRG Energy, El Segundo Energy Center is an environmentally compatible, combined cycle solution for peaking and intermediate load. The two units can achieve 300 megawatts (MW) in less than 10 minutes, allowing the plant to back up intermittent renewable power generation, such as wind and solar power, to maintain a steady, consistent and reliable supply of power to the grid.
For El Segundo Energy Center Siemens delivered two power islands – each featuring the main components, an SGT6-5000F gas turbine, an SST-800 steam turbine, an SGen6-1000A generator, an SGen6-100A-2P generator as well as a heat recovery steam generator, and an air-cooled heat exchanger. Siemens also supplied the complete electrical equipment and the SPPA-T3000 power plant
Wittelsbacherplatz 2, 80333 Munich, Germany Corporate Communications and Government Affairs Head: Stephan Heimbach
Fossil PowerGeneration Division Freyeslebenstr. 1, 91058 Erlangen
Reference number: EFP201309.065 e fp
The company also provided the engineering services and commissioning of the plant.
With the SGT6-5000F gas turbine integrated with a single-pressure, non-reheat bottoming cycle, and an air-cooled heat exchanger for steam condensing, this Flex- Plant-10 provides a net efficiency of nearly 49 percent – much higher in efficiency than conventional simple cycle solutions. This plant type is also environmentally friendly, as compared to conventional combined cycle technology with a reduction of 95 percent of CO start up emissions and low water consumption. Additionally, the fast start capability makes it well suited to stabilize the grid and balance fluctuating renewable power generation. In addition to having a small environmental footprint, El Segundo was optimized for the site size constraints. This also supported parallel demolition and construction efforts saving project schedule and cost.
“NRG and the state of California today moved one step closer to realizing a greener future in California,” said Martin Tartibi, Executive Vice President at Siemens Energy Solutions Americas. “Siemens Flex-Plant-10 technology is on the leading edge of where power generation in America is going in the future – fast, flexible and environmentally friendly.”
“Flex Plants with fast start technology are an environmentally friendly solution to seamlessly integrating renewable power into the grid. As a result of this project, the El Segundo Energy Center will be able to provide Californians with 550MW clean energy for decades to come,” said John Chillemi, President of NRG Energy’s West Region. “With Siemens as our partner, we were able to meet the challenges of permitting, constructing and operating in a highly populous and visible beach community in the South Bay Southern California area.”
Highly efficient combined cycle power plants are part of Siemens’ Environmental Portfolio. In fiscal 2012, revenue from the Portfolio totaled about €33 billion, making Siemens one of the world’s largest suppliers of ecofriendly technologies. In the same period, our products and solutions enabled customers to reduce their carbon dioxide (CO2) emissions by more than 330 million tons, an amount equal to the total annual CO2 emissions of Berlin, Delhi, Hong Kong, Istanbul, London, New York, Singapore and Tokyo.